Vliegtuigongeval op 18 MAR 1989 met McDonnell Douglas DC-9-33RC N931F - Saginaw, TX
ASN logo
 

Status:Accident investigation report completed and information captured
Datum:zaterdag 18 maart 1989
Tijd:02:16
Type:Silhouette image of generic DC93 model; specific model in this crash may look slightly different
McDonnell Douglas DC-9-33RC
Luchtvaartmaatschappij:Evergreen International Airlines
Registratie: N931F
Constructienummer: 47192/287
Bouwjaar: 1968
Aantal vlieguren:41931
Aantal vluchten:40808
Motoren: 2 Pratt & Whitney JT8D-9A
Bemanning:slachtoffers: 2 / inzittenden: 2
Passagiers:slachtoffers: 0 / inzittenden: 0
Totaal:slachtoffers: 2 / inzittenden: 2
Schade: Vernield
Gevolgen: Written off (damaged beyond repair)
Plaats:nabij Saginaw, TX (   Verenigde Staten)
Fase: Nadering (APR)
Soort vlucht:Vracht
Vliegveld van vertrek:Fort Worth-Carswell AFB, TX (FWH/KNFW), Verenigde Staten
Vliegveld van aankomst:Oklahoma City-Tinker AFB, OK (TIK/KTIK), Verenigde Staten
Vluchtnummer: 17
Beschrijving:
The DC-9 arrived at Carswell AFB at 01:12 CST after a flight from Kelly AFB. The aircraft was off-loaded and re-loaded with cargo by USAF personnel. The engines were then started at 02:04. The crew received taxi instructions for runway 17 and took off from this runway at 02:09. At (or immediately after) rotation, the main cargo door opened. An emergency was declared and the crew climbed to 2500 feet msl before entering a right turn. When about 5nm north of the airport the captain began a shallow turn to the right (for base leg). The aircraft crossed the extended centreline and the captain tightened the turn to establish their position relative to the runway threshold. In doing so, the air load on the door probably caused it to rapidly move to its full open over the top position. A sudden opening of the door would also have produced an unexpected change in the yawing and rolling moments. The captain, possibly partially disoriented, may not have sensed the increasing roll and nose tuck and thus failed to correct a changing attitude until a critical bank angle and loss of altitude had occurred. The DC-9 struck the ground in an inverted, nose down, left wing low attitude and disintegrated.
It appeared that the first officer, when closing the main cargo door, didn't hold the door control valve 'T' handle in the closed position long enough for the latching hooks to move into place over the door sill spools. External latched and locked indicators were applied incorrectly, so the first officer thought the door was latched properly when the handle was pointed more toward the 'locked' than the 'unlocked' chevron. It also appeared that one of the two open door warning light switches was malfunctioning. Because of their wiring, this malfunction made the entire door warning system ineffective.

Probable Cause:

PROBABLE CAUSE: "The loss of control of the airplane for undetermined reasons following the in-flight opening of the improperly latched cargo door.
Contributing to the accident were inadequate procedures used by Evergreen Airlines and approved by the FAA for pre-flight verification of external cargo door lock pin manual control handle, and the failure of McDonnell Douglas to provide flight crew guidance and emergency procedures for an in-flight opening of the cargo door. Also contributing to the accident was the failure of the FAA to mandate modification to the door-open warning system for DC-9 cargo-configured airplanes, given the previously known occurrences of in-flight door openings."

Accident investigation:

cover
Investigating agency: NTSB
Status: Investigation completed
Duration: 1 year and 1 months
Accident number: NTSB/AAR-90-02
Download report: Final report

Bronnen:
» NTSB/AAR-90/02


Veiligheidsmaatregelen

NTSB issued 2 Safety Recommendations

Show all...

Foto's

photo of DC-9-33RC-
photo of DC-9-33RC-N35UA
accident date: 18-03-1989
type: McDonnell Douglas DC-9-33RC
registration: N35UA
 

Kaart
Deze kaart geeft het vliegveld van vetrek weer en de geplande bestemming van de vlucht. De lijn tussen de vliegvelden geeft niet de exacte vliegroute weer.
De afstand tussen Fort Worth-Carswell AFB, TX en Oklahoma City-Tinker AFB, OK bedraagt 292 km (183 miles).
Accident location: Exact; as reported in the official accident report.

This information is not presented as the Flight Safety Foundation or the Aviation Safety Network’s opinion as to the cause of the accident. It is preliminary and is based on the facts as they are known at this time.
languages: languages

Share

DC-9-30

  • 662 built
  • 40e ongeval
  • 28e dodelijk ongeval
  • 26e zwaarste ongeval (toen het plaatsvond)
  • 35e zwaarste ongeval (op dit moment)
» safety profile

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org