Crash-aerien 18 MAY 2011 d'un Boeing 707-321B N707AR - Port Hueneme-Point Mugu NAS, CA (NTD)
ASN logo
 

Statuts:Accident investigation report completed and information captured
Date:mercredi 18 mai 2011
Heure:17:27
Type/Sous-type:Silhouette image of generic B703 model; specific model in this crash may look slightly different
Boeing 707-321B
Compagnie:Omega Air Refueling
Immatriculation: N707AR
Numéro de série: 20029/790
Année de Fabrication: 1969
Moteurs: 4 Pratt & Whitney JT3D-3B
Equipage:victimes: 0 / à bord: 3
Passagers:victimes: 0 / à bord: 0
Total:victimes: 0 / à bord: 3
Dégats de l'appareil: Détruit
Conséquences: Written off (damaged beyond repair)
Lieu de l'accident:Port Hueneme-Point Mugu NAS, CA (NTD) (   Etats-Unis d'Amérique)
Élévation des lieux de l'accident: 4 m (13 feet) amsl
Phase de vol: Au décollage (TOF)
Nature:Militaire
Aéroport de départ:Port Hueneme-Point Mugu NAS, CA (NTD/KNTD), Etats-Unis d'Amérique
Aéroport de destination:Port Hueneme-Point Mugu NAS, CA (NTD/KNTD), Etats-Unis d'Amérique
Numéro de vol: 70
Détails:
A Boeing 707-321B aerial tanker plane, registered N707AR, was destroyed when it suffered a runway excursion accident on takeoff from Port Hueneme-Point Mugu NAS, CA (NTD). There were three crew members on board and all escaped unhurt.
The flight crew indicated that they delayed their takeoff due to high wind conditions. Once the winds were within limits, they reported that startup was normal. Prior to takeoff, they decided to add 5 knots to their rotation speed, and power up slowly and as smoothly as possible.
The captain was the flying pilot. The first officer called critical engine failure recognition speed (V1) reference speed at 141 knots, and rotation speed (Vr) at 150 knots. The captain rotated the airplane, and it then lifted off about 7,000 feet down the 11,000-foot runway. About 20 feet above ground level (agl), the number two engine (left inboard) throttle lever slammed back to the idle position. The No. 2 engine pylon had separated from the left wing. The No. 2 engine nacelle and pylon assembly struck the No. 1 engine nacelle, causing the No. 1 engine inlet cowl to separate, which degraded the engine’s ability to produce thrust and resulted in a significant loss of thrust on the left side of the airplane.
The flight crew reported that the airplane began to drift to the left and descend. The captain lowered the pitch slightly and leveled the wings just prior to the airplane contacting the runway. He informed the other crew members that they were going to put it back down. He placed the throttle levers in the idle position, and activated the speed brakes. The airplane departed the left side of the runway surface; the crew reported a couple of impacts and then one final violent impact prior to the airplane coming to rest in a wetland marsh.
The flight crew had to force the cockpit door open due to debris that had piled up against it. They noted significant damage from the forward galley aft, and a large fire in the vicinity of the left wing. They opened the left main cabin door, and deployed the slide. They exited into the mud, and made it to dry land and away from the burning wreckage.
Investigators examined the wreckage at the accident site. The observed debris field extended 4,120 feet on a heading of 218 degrees. The first pieces of wreckage found along the debris path were fragments of the number two (left inboard) engine pylon; they were just past taxiway Alpha 2, about 7,500 feet from the beginning of runway 21. The number one engine (left outboard) nose cowl was about 450 feet further into the debris field and left of the runway surface in the grass infield.
The number two engine nose cowl was near the runway arresting gear on the left side of the runway at the 8,500 foot point. The number two engine was about 230 feet further, and on the left side of the runway surface.
The airplane departed the asphalt surface near taxiway Alpha 1, which was 9,500 feet from the departure end of the runway. Ground scars continued through the grass infield to taxiway Alpha at the end of the runway. The number one engine was in the grass infield near taxiway Alpha.
The main wreckage came to rest in a wetland marsh left of the runway overrun, and caught fire. Fire consumed the top of the cabin and the cockpit. The main wreckage consisted of the cockpit, cabin, right wing with the number three (right inboard) engine partially attached, empennage, and the inboard half of the left wing, which sustained thermal damage and was under water. Scattered debris aft of the main wreckage included the nose gear, remnants of the burned outboard left wing, right main landing gear truck, and number four (right outboard) engine.
A visual examination of a fracture surface on the number two engine pylon inboard mid-spar support fitting determined that it was flat and discolored with an arcing terminus.
The aircraft was registered and operated by Omega Air Inc., an air refueling contractor that uses specially-equipped and converted civilian airplanes to serve as air refueling platforms for the military. The flight was conducted under the provisions of a contract between Omega and the US Naval Air Systems Command (NAVAIR) to provide aerial refueling of Navy F/A-18s in offshore warning area airspace.

Probable Cause:

PROBABLE CAUSE: "The NTSB determines that the probable cause of this accident was the failure of a midspar fitting, which was susceptible to fatigue cracking and should have been replaced with a newer, more fatigue-resistant version of the fitting as required by an airworthiness directive. Also causal was an erroneous maintenance entry made by a previous aircraft owner, which incorrectly reflected that the newer fitting had been installed."

Accident investigation:

cover
Investigating agency: NTSB
Status: Investigation completed
Duration: 2 years and 10 months
Accident number: DCA11PA075
Download report: Summary report

Sources:
» FAA
» NTSB


Photos

photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
photo of Boeing-707-321B-N707AR
accident date: 18-05-2011
type: Boeing 707-321B
registration: N707AR
 

Video, social media

Plan

Les informations ci-dessus ne représentent pas l'opinion de la 'Flight Safety Foundation' ou de 'Aviation Safety Network' sur les causes de l'accident. Ces informations prélimimaires sont basées sur les faits tel qu'ils sont connus à ce jour.
languages: languages

Share

Boeing 707

  • 858 built
  • 173ème loss
» safety profile

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org