ASN Wikibase Occurrence # 210079
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can submit corrected information.
| Date: | Saturday 28 April 2018 |
| Time: | 17:15 |
| Type: |  Piper PA-28R-200 Arrow II |
| Owner/operator: | Private |
| Registration: | N4363F |
| MSN: | 28R-7635406 |
| Year of manufacture: | 1976 |
| Total airframe hrs: | 5515 hours |
| Engine model: | Lycoming IO-360-C1C |
| Fatalities: | Fatalities: 1 / Occupants: 3 |
| Aircraft damage: | Substantial |
| Category: | Accident |
| Location: | Forsyth County, west of Gainesville, GA -
 United States of America
|
| Phase: | Landing |
| Nature: | Training |
| Departure airport: | Lawrenceville, GA (LZU) |
| Lawrenceville, GA (LZU) | |
| Investigating agency: | NTSB |
| Confidence Rating: |  Accident investigation report completed and information captured |
The commercial pilot receiving instruction and a flight instructor were conducting a local instructional flight when the engine lost partial power and oil obscured the front windscreen. The instructor took control of the airplane and maneuvered toward a highway on which to conduct a forced landing; the airplane struck power lines and a vehicle before veering off the road and down a steep embankment, where it came to rest inverted.
Examination of the engine revealed that the No. 2 cylinder had separated from the cylinder mounting deck. The No. 2 cylinder rocker box cover and a pushrod tube were protruding from the left forward side of the cowling. The No. 2 cylinder connecting rod was protruding through the top of the cowling. The No. 2 cylinder base studs and thru bolts remained in the crankcase and were fractured at their threaded section. Metallurgical examination revealed that each of the fractured surfaces exhibited evidence of crack arrest marks consistent with fatigue cracking and microvoid coalescence features typical of overstress separation. The crankcase web mating surfaces at the Nos. 2, 3 and 4 bearing journals exhibited pitting consistent with fretting, which is typically a result of inadequate preload tension or loss of preload tension to the fasteners that secure the cylinder to the engine. The inadequate or loss of preload resulted in fatigue cracking of the No. 2 cylinder studs and thru-bolts, and the subsequent separation of the cylinder.
According to maintenance records, the engine underwent a major overhaul about 4 years before the accident and had accrued 1,071.11 hours since the last overhaul. At the time of the overhaul, the crankcase was reassembled, and all four cylinders were installed. It could not be determined if the thru-bolts and studs were improperly tightened by maintenance personnel at the time of the overhaul or during an undocumented maintenance action that was performed after the overhaul.
Toxicology testing of the flight instructor revealed an unquantifiable amount of doxylamine, a sedating antihistamine that was well below that considered to cause significant effects. Therefore, it is unlikely that the pilot's use of doxylamine contributed to his inability to successfully perform a forced landing on a highway.
Probable Cause: A partial loss of engine power due to inadequate thru-bolt and stud preload tension by undetermined maintenance personnel, which resulted in fretting between the engine crankcase halves, and the subsequent separation of the No. 2 cylinder due to the fatigue failure of the No. 2 cylinder stud/thru bolts.
Accident investigation:
 |
|
Sources:
NTSB
FAA register: http://registry.faa.gov/aircraftinquiry/NNum_Results.aspx?NNumbertxt=4363F
Location
Media:
🛩️🇺🇸One person is dead and two others are injured after a Piper PA-28 crashed in Gainesville, Forsyth County on Saturday evening, according to the Forsyth County Sheriff\'s Office. A car was hit by the plane, but no one in the car was hurt. https://t.co/T1sJ3kfu5K pic.twitter.com/RXfOyAShB9
— Planes Of Legend (@PlanesOfLegend) 29 avril 2018
Revision history:
| Date/time | Contributor | Updates |
|---|---|---|
| 29-Apr-2018 00:57 | Geno | Added |
| 29-Apr-2018 05:34 | Iceman 29 | Updated [Time, Source, Embed code] |
| 29-Apr-2018 16:12 | Anon. | Updated [Embed code, Damage] |
| 22-Dec-2019 14:15 | ASN Update Bot | Updated [Time, Operator, Nature, Departure airport, Destination airport, Source, Embed code, Damage, Narrative, Accident report, ] |
Corrections or additions? ... Edit this accident description
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2024 Flight Safety Foundation