Vliegtuigongeval op 10 JAN 1954 met de Havilland DH-106 Comet 1 G-ALYP - Elba
ASN logo
 
 
Status:Accident investigation report completed and information captured
Datum:zondag 10 januari 1954
Tijd:11:00
Type:Silhouette image of generic COMT model; specific model in this crash may look slightly different
de Havilland DH-106 Comet 1
Luchtvaartmaatschappij:British Overseas Airways Corporation - BOAC
Registratie: G-ALYP
Constructienummer: 06003
Bouwjaar: 1951-01-09 (3 years )
Aantal vlieguren:3681
Motoren: 4 de Havilland Ghost 50
Bemanning:slachtoffers: 6 / inzittenden: 6
Passagiers:slachtoffers: 29 / inzittenden: 29
Totaal:slachtoffers: 35 / inzittenden: 35
Schade: Vernield
Gevolgen: Written off (damaged beyond repair)
Plaats:16 km (10 mijl) S van Elba (   Italië)
Fase: Kruisvlucht (ENR)
Soort vlucht:Internationale lijnvlucht
Vliegveld van vertrek:Roma-Ciampino Airport (CIA/LIRA), Italië
Vliegveld van aankomst:London Airport (LHR/EGLL), Verenigd Koninkrijk
Vluchtnummer: 781
Beschrijving:
Comet G-ALYP left Rome-Ciampino Airport (CIA) at 10:31 on a flight to London. After taking off the aircraft was in touch with Ciampino control tower by radio telephone and from time to time reported its position. These reports indicated that the flight was proceeding according to the B.O.A.C. flight plan and the last of them, which was received at 10:50, said that the aircraft was over the Orbetello Beacon. The captain of another B.O.A.C. aircraft, Argonaut G-ALHJ, gave evidence of communications which passed between him and G-ALYP. The last such message received by the Argonaut began " George How Jig from George Yoke Peter did you get my " and then broke off. At that time, approximately 10:51, the aircraft was probably approaching a height of 27,000 feet. The Comet descended and crashed into the sea off the Island of Elba.
Initial examination and reconstruction of the wreckage of G-ALYP revealed several signs of inflight break-up. Shreds of cabin carpet were found trapped in the remains of the Comet's tail section; The imprint of a coin was found on a fuselage panel from the rear of the aircraft; and Smears and scoring on the rear fuselage were tested and found to be consistent to the paint applied to the passenger seats of the Comet.
When most of the wreckage was recovered, investigators found that fractures started on the roof, a window then smashed into the back elevators, the back fuselage then tore away, the outer wing structure fell, then the outer wing tips and finally the cockpit broke away and fuel from the wings set the debris on fire.
To find out what caused the first failure, BOAC donated G-ALYU for testing. The airframe was put in a huge water tank, the tank was filled, and water was pumped into the plane to simulate flight conditions. After the equivalent of only 3,000 flights investigators at the Royal Aircraft Establishment (RAE) were able to conclude that the crash had been due to failure of the pressure cabin at the forward ADF window in the roof. This 'window' was in fact one of two apertures for the aerials of an electronic navigation system in which opaque fibreglass panels took the place of the window 'glass.' The failure was a result of metal fatigue caused by the repeated pressurization and de-pressurization of the aircraft cabin. Another worrying fact was that the supports around the windows were only riveted not glued, as the original specifications for the aircraft had called for. The problem was exacerbated by the punch rivet construction technique employed. Unlike drill riveting, the imperfect nature of the hole created by punch riveting may cause the start of fatigue cracks around the rivet.
The Comet's pressure cabin had been designed to a safety factor comfortably in excess of that required by British Civil Airworthiness Requirements (2.5x P as opposed to the requirement of 1.33x P and an ultimate load of 2x P, P being the cabin 'Proof' pressure) and the accident caused a revision in the estimates of the safe loading strength requirements of airliner pressure cabins.

Probable Cause:

PROBABLE CAUSE: "We have formed the opinion that the accident at Elba was caused by structural failure of the pressure cabin, brought about by fatigue. We reach this opinion for the following reasons: -
(i) The low fatigue resistance of the cabin has been demonstrated by the test described in Part 3, and the test result is interpretable as meaning that there was, at the age of the Elba aeroplanes a definite risk of fatigue failure occurring.
(ii) The cabin was the first part of the aeroplane to fail in the Elba accident.
(iii) The wreckage indicates that the failure in the cabin was of the same basic type as that produced in the fatigue test.
(iv) This explanation seems to us to be consistent with all the circumstantial evidence.
(v) The only other defects found in the aeroplane were not concerned at Elba, as demonstrated by the wreckage. "

Bronnen:
» ICAO Accident Digest, Circular 47-AN/42 (16-45)
» Report of the Public Inquiry into the causes and circumstances of the accident which occurred on the 10th January, 1954, to the Comet aircraft G-ALYP


Foto's

photo of de-Havilland-DH-106-Comet-1-G-ALYP
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYP
photo of de-Havilland-DH-106-Comet-1-G-ALYP
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYP
photo of de-Havilland-DH-106-Comet-1-G-ALYP
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYP
photo of de-Havilland-DH-106-Comet-1-G-ALYP
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYP
photo of de-Havilland-DH-106-Comet-1-G-ALYP
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYP
photo of de-Havilland-DH-106-Comet-1-G-ALYU
accident date: 10-01-1954
type: de Havilland DH-106 Comet 1
registration: G-ALYU
 

Kaart
Deze kaart geeft het vliegveld van vetrek weer en de geplande bestemming van de vlucht. De lijn tussen de vliegvelden geeft niet de exacte vliegroute weer.
De afstand tussen Roma-Ciampino Airport en London Airport bedraagt 1452 km (908 miles).
Accident location: Approximate; accuracy within a few kilometers.

This information is not presented as the Flight Safety Foundation or the Aviation Safety Network’s opinion as to the cause of the accident. It is preliminary and is based on the facts as they are known at this time.
languages: languages

Share

DH-106 Comet

  • 112 built
  • 6e ongeval
  • 3e dodelijk ongeval
  • 2e zwaarste ongeval (toen het plaatsvond)
  • 6e zwaarste ongeval (op dit moment)
» safety profile

 Italië
  • The zwaarste ongeval (toen het plaatsvond)
  • 12e zwaarste ongeval (op dit moment)
» safety profile

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org