Beschrijving:
Lauda Air Flight 004 was a scheduled service from Hong Kong (HKG) back to Vienna (VIE), Austria. An intermediate stop was made in Bangkok (BKK), Thailand. The flight departed Bangkok at 23:02 hours. Some five minutes after takeoff the pilot-in-command stated "that keeps coming on," referring to a REV ISLN advisory warning. This indication appears when a fault has been detected in the thrust reverser system. The crew discussed the REV ISLN indication for about four and one-half minutes. The co-pilot read information from the Airplane Quick Reference Handbook as follows: "Additional systems failures may cause in- flight deployment" and "Expect normal reverser operation after landing." The pilot-in-command remarked "....its not just on, its coming on and off," he said, "...its just an advisory thing...," and shortly thereafter stated, "could be some moisture in there or something." At 23:12, the co-pilot advised the pilot-in-command that there was need for, "a little bit of rudder trim to the left." Fifteen minutes and one second into the flight the co-pilot exclaimed, "ah reverser's deployed," accompanied by sound similar to airframe shuddering, sounds of metallic snaps and the pilot-in-command stating "here wait a minute." With the deployment of the no. 1 engine thrust reverser, engine thrust was reduced to idle. Aerodynamic effects of the reverser plume in-flight during the engine run down to idle resulted in a 25 percent lift loss across the wing. The airplane stalled and entered an uncontrolled descent. Buffeting, maneuvering overload, and excessive speed caused pieces of the rudder and the left elevator to separate. This was followed by the down-and-aft separation of most of the right horizontal stabilizer from maneuvering overloads, as the crew attempted to control the airplane and arrest the high-speed descent. A torsional overload then caused the separation of the vertical and left horizontal stabilizers. The loss of the tail resulted in a sharp nose-over of the airplane, producing excessive negative loading of the wing. A downward wing failure was probably followed by the breakup of the fuselage. The complete breakup of the tail, wing, and fuselage occurred in a matter of seconds. The wreckage fell in mountainous jungle terrain.
PROBALE CAUSE: "The Accident Investigation Committee of the Government of Thailand determines the probable cause of this accident to be uncommanded in-flight deployment of the left engine thrust reverser, which resulted in loss of flight path control. The specific cause of the thrust reverser deployment has not been positively identified."
» Aviation Week & Space Technology 03.06.1991 (32), 10.06.91 (28-30)
accident date: 26-05-1991
type: Boeing 767-3Z9ER
registration: OE-LAV
| Status: | Accident investigation report completed and information captured |
| Datum: | zondag 26 mei 1991 |
| Tijd: | 23:17 |
| Type: |  Boeing 767-3Z9ER |
| Luchtvaartmaatschappij: | Lauda Air |
| Registratie: | OE-LAV |
| Constructienummer: | 24628/283 |
| Bouwjaar: | 1989-09-26 (1 year 8 months) |
| Aantal vlieguren: | 7429 |
| Aantal vluchten: | 1132 |
| Motoren: | 2 Pratt & Whitney PW4060 |
| Bemanning: | slachtoffers: 10 / inzittenden: 10 |
| Passagiers: | slachtoffers: 213 / inzittenden: 213 |
| Totaal: | slachtoffers: 223 / inzittenden: 223 |
| Schade: | Vernield |
| Gevolgen: | Written off (damaged beyond repair) |
| Plaats: | 5,6 km (3.5 mijl) NNE of Phu Toey ( Thailand)
|
| Fase: | Kruisvlucht (ENR) |
| Soort vlucht: | Internationale lijnvlucht |
| Vliegveld van vertrek: | Bangkok-Don Muang International Airport (BKK/VTBD), Thailand |
| Wien-Schwechat International Airport (VIE/LOWW), Oostenrijk | |
| Vluchtnummer: | NG004 |
Lauda Air Flight 004 was a scheduled service from Hong Kong (HKG) back to Vienna (VIE), Austria. An intermediate stop was made in Bangkok (BKK), Thailand. The flight departed Bangkok at 23:02 hours. Some five minutes after takeoff the pilot-in-command stated "that keeps coming on," referring to a REV ISLN advisory warning. This indication appears when a fault has been detected in the thrust reverser system. The crew discussed the REV ISLN indication for about four and one-half minutes. The co-pilot read information from the Airplane Quick Reference Handbook as follows: "Additional systems failures may cause in- flight deployment" and "Expect normal reverser operation after landing." The pilot-in-command remarked "....its not just on, its coming on and off," he said, "...its just an advisory thing...," and shortly thereafter stated, "could be some moisture in there or something." At 23:12, the co-pilot advised the pilot-in-command that there was need for, "a little bit of rudder trim to the left." Fifteen minutes and one second into the flight the co-pilot exclaimed, "ah reverser's deployed," accompanied by sound similar to airframe shuddering, sounds of metallic snaps and the pilot-in-command stating "here wait a minute." With the deployment of the no. 1 engine thrust reverser, engine thrust was reduced to idle. Aerodynamic effects of the reverser plume in-flight during the engine run down to idle resulted in a 25 percent lift loss across the wing. The airplane stalled and entered an uncontrolled descent. Buffeting, maneuvering overload, and excessive speed caused pieces of the rudder and the left elevator to separate. This was followed by the down-and-aft separation of most of the right horizontal stabilizer from maneuvering overloads, as the crew attempted to control the airplane and arrest the high-speed descent. A torsional overload then caused the separation of the vertical and left horizontal stabilizers. The loss of the tail resulted in a sharp nose-over of the airplane, producing excessive negative loading of the wing. A downward wing failure was probably followed by the breakup of the fuselage. The complete breakup of the tail, wing, and fuselage occurred in a matter of seconds. The wreckage fell in mountainous jungle terrain.
Probable Cause:
PROBALE CAUSE: "The Accident Investigation Committee of the Government of Thailand determines the probable cause of this accident to be uncommanded in-flight deployment of the left engine thrust reverser, which resulted in loss of flight path control. The specific cause of the thrust reverser deployment has not been positively identified."
Bronnen:
» SKYbrary » Aviation Week & Space Technology 03.06.1991 (32), 10.06.91 (28-30)
Veiligheidsmaatregelen
The Thai Aircraft Accident Investigation Committee recommended that the United States FAA examine the certification philosophy of all airplane certificated with ground only engine thrust reverser systems to provide appropriate design safeguards to prevent in-flight deployment.
The Aircraft Accident Investigation Committee also recommends that the FAA revise the certification standards for current and future airplane flight recorders intended for use in accident investigation to protect and preserve the recorded information from the conditions of prolonged thermal exposure that can be expected in accidents which occur in locations that are inaccessible for fire fighting efforts. FAA issued 6 Airworthiness Directives
NTSB issued 4 Safety Recommendations
Show all...
The Aircraft Accident Investigation Committee also recommends that the FAA revise the certification standards for current and future airplane flight recorders intended for use in accident investigation to protect and preserve the recorded information from the conditions of prolonged thermal exposure that can be expected in accidents which occur in locations that are inaccessible for fire fighting efforts. FAA issued 6 Airworthiness Directives
NTSB issued 4 Safety Recommendations
Show all...
Foto's
accident date: 26-05-1991
type: Boeing 767-3Z9ER
registration: OE-LAV
Kaart
Deze kaart geeft het vliegveld van vetrek weer en de geplande bestemming van de vlucht. De lijn tussen de vliegvelden geeft niet de exacte vliegroute weer.
De afstand tussen Bangkok-Don Muang International Airport en Wien-Schwechat International Airport bedraagt 8375 km (5235 miles).
Accident location: Exact; as reported in the official accident report.
De afstand tussen Bangkok-Don Muang International Airport en Wien-Schwechat International Airport bedraagt 8375 km (5235 miles).
Accident location: Exact; as reported in the official accident report.
This information is not presented as the Flight Safety Foundation or the Aviation Safety Network’s opinion as to the cause of the accident. It is preliminary and is based on the facts as they are known at this time.
languages: 
Thailand
Share
Boeing 767
- 1273+ built
- 3e ongeval
- The first dodelijk ongeval
- The zwaarste ongeval (toen het plaatsvond)
- 3e zwaarste ongeval (op dit moment)
Thailand- The zwaarste ongeval
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2023 Flight Safety Foundation