ASN Wikibase Occurrence # 137553
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can submit corrected information.
| Date: | Saturday 23 July 2011 |
| Time: | 12:33 |
| Type: |  Cirrus SR22 |
| Owner/operator: | Private |
| Registration: | N122HB |
| MSN: | 0517 |
| Year of manufacture: | 2003 |
| Total airframe hrs: | 1235 hours |
| Engine model: | Continental IO-550-N |
| Fatalities: | Fatalities: 2 / Occupants: 3 |
| Aircraft damage: | Substantial |
| Category: | Accident |
| Location: | Near Palm Bay, Florida -
 United States of America
|
| Phase: | En route |
| Nature: | Private |
| Departure airport: | St. Petersburg, FL (SPG) |
| Valkaria, FL (X59) | |
| Investigating agency: | NTSB |
| Confidence Rating: |  Accident investigation report completed and information captured |
The surviving passenger stated that the pilot flew the airplane on an uneventful 56-minute flight earlier on the day of the accident. According to data from the multifunction display, the oil pressure was in the normal green arc range (30 to 60 psi) during the entire flight. After landing, no maintenance or servicing was performed. Before takeoff for the accident flight, the pilot performed a walk-around inspection of the airplane, which would require, in part, a check of the oil quantity.
According to GPS and other recorded flight data, about 17 minutes after takeoff, the oil pressure decreased below the lower end of the normal operating range; at the time, the airplane was flying in an easterly direction about 10 nautical miles west of an airport with runways of more-than-adequate length for the pilot to divert. Rather than divert, the pilot continued toward the destination. Although the oil temperature remained in the normal operating range, the oil pressure continued to decrease. Both indications would have been available to the pilot either on the multifunction display or on the analog combination oil pressure/oil temperature gauge.
While the airplane continued toward the destination, the oil pressure decreased to 10 psi, and the pilot maintained the engine power setting at 2,400 rpm (the maximum setting is 2,700 rpm). About 46 minutes after takeoff, with the engine rpm still set at 2,400 rpm, the pilot declared an emergency and advised the controller that smoke was coming from the engine. Unable to fly to suggested airports, the pilot initiated an approach for a forced landing to a large open area containing east/west- and north/south-oriented paved roads.
Witnesses reported that the engine was sputtering and “coughing” but did not note smoke trailing the airplane. For the last 1 minute 12 seconds of flight, the engine rpm decreased from 2,400 to 1,700. While descending with the autopilot disengaged and at 74 knots indicated airspeed, the airplane banked 55 degrees to the right, stalled, pitched nose-down, and impacted the ground.
Examination of the wreckage revealed oil covering the bottom left side of the fuselage from the engine firewall to the tailcone, consistent with the crankcase being pressurized and blowing oil out of the air/oil separator. Examination of the engine revealed that the oil gauge rod and cap assembly had separated from the oil filler tube and was found near the engine and propeller impact crater. Neither the oil gauge rod and cap assembly nor the oil filler breather tube were impact damaged, suggesting that the assembly was improperly secured. Although the No. 4 cylinder piston was fractured and the fracture surfaces exhibited widely spaced crack propagation marks consistent with progressive crack growth under cyclic stresses, the cyclic load was at or above the yield strength of the material. Therefore, the No. 4 cylinder piston did not contribute to the loss of engine oil supply. Examination of the ignition, lubrication, air induction, and fuel injection systems did not note any discrepancies that contributed to the catastrophic failure of the engine.
The catastrophic failure of the engine was consistent with oil starvation due to the crankcase becoming pressurized because of an unsecured oil gauge rod and cap assembly. Postaccident examination of the pistons, piston rings, and crankshaft nose seal did not indicate other typical scenarios of crankcase pressurization. A previous NTSB accident investigation of a different airplane with the same engine model determined that an unsecured oil cap allowed the crankcase to become pressurized and the oil to be vented overboard, causing subsequent catastrophic failure of the engine due to oil starvation.
The pilot’s decision to continue the flight with decreasing or low oil pressure rather than land at a suitable airport nearby and his continued operation of the engine at a high rpm setting contradicted the emergency procedures section of the pilot operating handbook and Federal Aviation Administration-approved flight manual, whic
Probable Cause: The pilot’s failure to maintain adequate airspeed while maneuvering for a forced landing, resulting in an inadvertent aerodynamic stall. Contributing to the accident were the pilot’s failure to secure the oil gauge rod and cap assembly before flight and his decision not to land immediately following loss of oil pressure, which resulted in the total loss of engine power due to oil starvation.
Accident investigation:
 |
|
Sources:
NTSB
Location
Revision history:
| Date/time | Contributor | Updates |
|---|---|---|
| 23-Jul-2011 15:06 | gerard57 | Added |
| 23-Jul-2011 18:33 | RobertMB | Updated [Aircraft type, Source, Damage, Narrative] |
| 24-Jul-2011 02:17 | RobertMB | Updated [Time, Registration, Cn, Operator, Location, Departure airport, Destination airport, Source, Narrative] |
| 24-Jul-2011 02:19 | RobertMB | Updated [Destination airport] |
| 24-Jul-2011 10:33 | RobertMB | Updated [Total fatalities, Narrative] |
| 24-Jul-2011 15:01 | RobertMB | Updated [Total fatalities, Narrative] |
| 21-Dec-2016 19:26 | ASN Update Bot | Updated [Time, Damage, Category, Investigating agency] |
| 27-Nov-2017 17:02 | ASN Update Bot | Updated [Operator, Other fatalities, Departure airport, Destination airport, Source, Narrative] |
Corrections or additions? ... Edit this accident description
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2024 Flight Safety Foundation