ASN Wikibase Occurrence # 139915
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information.
If you feel this information is incomplete or incorrect, you can submit corrected information.
| Date: | Tuesday 15 November 2011 |
| Time: | 08:37 |
| Type: |  Bell UH-1H (Williams mod.) |
| Owner/operator: | Airwest Helicopters |
| Registration: | N502AW |
| MSN: | 69-15340 |
| Year of manufacture: | 1970 |
| Engine model: | Lycoming T53-L-13 |
| Fatalities: | Fatalities: 0 / Occupants: 1 |
| Aircraft damage: | Substantial |
| Category: | Accident |
| Location: | About three miles west the Valle Airport - K40G, Grand Canyon, AZ -
 United States of America
|
| Phase: | En route |
| Nature: | Unknown |
| Departure airport: | Grand Canyon, AZ (40G) |
| Supai, AZ | |
| Investigating agency: | NTSB |
| Confidence Rating: |  Accident investigation report completed and information captured |
According to the pilot, the helicopter was about 500 ft above ground level (agl) when he saw the master caution warning light illuminate; he then saw that the low transmission oil pressure light was also illuminated. He immediately maneuvered away from power lines and set up an approach to land. While descending, the helicopter yawed left and right, and, about 10 ft agl with the airspeed almost at 0, the main rotor speed slowed and then stopped, and the helicopter subsequently fell to the ground. The pilot reported that the engine continued to operate for about 15 seconds after impact.
An on-scene examination revealed that both main rotor blades remained intact with no leading edge damage. Examination of the helicopter revealed a band of discoloration around the circumference of the transmission case near the main rotor reduction gear assembly; localized paint peeling was also noted. There were no oil stains or residue on the transmission case.
During the subsequent transmission disassembly, the mast was found coated in metal debris along its length, and the mast bearing was found coated in oil. Molten metal pieces were found in the upper planetary gears, ring gear, and sun gear, consistent with insufficient lubrication. The lower planetary gears sustained significant damage from the molten metal pieces. There was no damage to the transmission oil pump, oil was present in the oil pump cavity, and some debris and scoring were evident on the housing.
Examination of the passages within the transmission oil manifold revealed medium-to-high density particles in several of the passages, but none of the passages were blocked; particles were also found in the chip detector. The particles were identified as being generally composed of metals commonly used in gears, housings, and bushings. The damage to the transmission indicated that it likely seized as a result of an overtemperature condition due to a lack of lubrication. Due to the severity of the damage, the reason for the lack of lubrication could not be determined.
Probable Cause: The loss of main rotor power due to a main rotor transmission failure from a lack of lubrication.
Accident investigation:
 |
|
Sources:
NTSB
FAA register: http://azdailysun.com/news/local/helicopter-crashes-south-of-grand-canyon/article_cad99f84-0fbd-11e1-af2c-001cc4c03286.html
[LINK NOT WORKING ANYMORE:http://tucsoncitizen.com/arizona-news/2011/11/15/helicopter-pilot-hurt-in-hard-landing-near-grand-canyon-airport/]
https://www.faa.gov/data_research/accident_incident/preliminary_data/events01/media/01_502AW.txt
http://registry.faa.gov/aircraftinquiry/NNum_Results.aspx?NNumbertxt=502AW&x=0&y=0
http://www.airnav.com/airport/40G
http://jetphotos.net/viewphoto.php?id=7194888 (photo)
Location
Revision history:
| Date/time | Contributor | Updates |
|---|---|---|
| 16-Nov-2011 05:44 | gerard57 | Added |
| 16-Nov-2011 06:33 | RobertMB | Updated [Time, Aircraft type, Registration, Cn, Operator, Location, Departure airport, Destination airport, Source, Narrative] |
| 17-Nov-2011 03:25 | Geno | Updated [Aircraft type, Cn, Location, Departure airport, Source, Narrative] |
| 17-Nov-2011 14:21 | RobertMB | Updated [Aircraft type, Cn, Location, Departure airport, Narrative] |
| 21-Dec-2016 19:26 | ASN Update Bot | Updated [Time, Damage, Category, Investigating agency] |
| 27-Nov-2017 17:24 | ASN Update Bot | Updated [Cn, Operator, Other fatalities, Nature, Departure airport, Destination airport, Source, Narrative] |
Corrections or additions? ... Edit this accident description
The Aviation Safety Network is an exclusive service provided by:
Quick Links:
| ASN Home | Send Correction / Feedback |
| FSF Home | Disclaimer | Copyright |
| Contact Us | Privacy Policy |
| Press / Media |
CONNECT WITH US:
©2024 Flight Safety Foundation