Accident Lancair 235 N235MW,
ASN logo
ASN Wikibase Occurrence # 145048
 
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information. If you feel this information is incomplete or incorrect, you can submit corrected information.

Date:Saturday 14 April 2012
Time:13:30
Type:Silhouette image of generic LNC2 model; specific model in this crash may look slightly different    
Lancair 235
Owner/operator:Private
Registration: N235MW
MSN: MW06
Total airframe hrs:324 hours
Engine model:Lycoming O-235-L2C
Fatalities:Fatalities: 1 / Occupants: 1
Aircraft damage: Substantial
Category:Accident
Location:Hudson, KY -   United States of America
Phase: En route
Nature:Private
Departure airport:Rough River State Park Airport, KY (2I3)
Destination airport:Louisville Muhammad Ali International Airport, KY (LOU)
Investigating agency: NTSB
Confidence Rating: Accident investigation report completed and information captured
Narrative:
About 2 months before the accident, the homebuilt experimental airplane began to experience electrical problems. This was first discovered when the landing gear hesitated before extending. To extend the landing gear during subsequent flights, the pilot shut off all nonessential electrical equipment in the airplane, extended the landing gear, and then turned the electrical equipment back on. On the morning of the accident, while on approach at the destination airport, the electrical system failed and the landing gear would not extend. The pilot reached behind his seat, "jiggled" the airplane's battery cables, and was able to restore electricity and extend the landing gear. He landed the airplane uneventfully and shut the airplane down.

After shutdown, the airplane had to be "hand propped" to be restarted; however, the pilot could not adjust the electrically-controlled propeller to the proper pitch for takeoff. The pilot removed the battery from his airplane and returned to his home airport with another pilot. He charged two batteries and returned with the charged batteries to his airplane. The pilot installed one of the batteries in his airplane and stated that if he could get the airplane started, he would fly it back to his home airport with the landing gear down.

The airplane started after three attempts, and the pilot taxied to the runway. A witness observed fuel exiting the right wingtip fuel vent during taxi, indicating that there was fuel in the main wing tanks. The pilot departed, and while he was en route, he transmitted that he was experiencing a problem and that he was going to land in a field. A witness observed the airplane at low altitude but did not hear any engine noise as the airplane passed him. The airplane then maneuvered around a barn and touched down in a level attitude in a harvested corn field. The airplane’s landing gear collapsed, and the airplane nosed over.

Examination of the airplane and engine revealed no evidence of any preimpact mechanical failure or malfunction; however, examination of the propeller indicated that the engine was not producing power, and the header tank, which supplied fuel to the engine, contained only 8 ounces of fuel. The inline fuel filter and fuel strainer contained only trace amounts of fuel. Further examination revealed that the header tank received its fuel from the wing tanks via electrically-operated transfer pumps. Examination of a connector that connected the positive battery cable to the master relay revealed that the inside of the connector's collar, which had been soldered and crimped onto the battery cable, was moist and heavily corroded, and that not all of the battery cable's wire strands were in contact with the collar of the connector. Further examination revealed that the end of battery cable that had been retained by the connector's collar was also moist and exhibited significant corrosion, indicating that the connector had been exposed to a corrosive environment. Examination of the battery box revealed corrosion and electrolyte (sulfuric acid) residue, which indicated that a release of electrolyte from a previously-installed battery had occurred. Additionally, comparison of the position of the positive battery cable's run from the battery terminal to the master contactor revealed that the master contactor was mounted below the top of the battery and that no precautions had been taken to prevent liquid from running down the cable into the base of the connector.

With a failure of the electrical wiring interconnect, the airplane’s battery was unable to power the electrical system. Because the fuel transfer pumps were electrically powered, fuel was not transferred to the header tank to feed the engine, and a loss of engine power occurred. Additionally, without electrical power, the propeller could not be adjusted and the electrically-actuated landing gear could not be retracted to reduce drag and extend the airplane’s glide. Further, because the wing flaps were electrically operated, they could not be extended during the landing, thus the airplane touched down at a higher speed (13 or more knots) than normal touchdown speed, which reduced the survivability of the accident when the airplane nosed over.

Probable Cause: The pilot's decision to operate the airplane with known electrical system problems, which resulted in the in-flight failure of the electrical wiring interconnect system, loss of electrical power, and subsequent fuel starvation and loss of engine power.

Accident investigation:
cover
  
Investigating agency: NTSB
Report number: ERA12FA280
Status: Investigation completed
Duration: 1 year and 4 months
Download report: Final report

Sources:

NTSB
FAA register: https://www.whas11.com/home/Plane-crash-in-Harned-Ky-147446915.html
http://www.wdrb.com/story/17452236/plane-crashes-in-breckinridge-county
http://registry.faa.gov/aircraftinquiry/NNum_Results.aspx?NNumbertxt=235mw
https://www.ntsb.gov/aviationquery/brief.aspx?ev_id=20120414X83122&key=1

Location

Images:


Photo(c): NTSB

Revision history:

Date/timeContributorUpdates
14-Apr-2012 14:25 gerard57 Added
14-Apr-2012 16:23 Alpine Flight Updated [Time, Aircraft type, Registration, Other fatalities, Damage, Narrative]
14-Apr-2012 17:25 RobertMB Updated [Location, Source, Narrative]
14-Apr-2012 19:42 Geno Updated [Aircraft type, Registration, Cn, Location, Narrative]
14-Apr-2012 19:56 Geno Updated [Location, Departure airport, Destination airport, Source, Narrative]
04-May-2012 20:05 Geno Updated [Time, Source]
21-Dec-2016 19:28 ASN Update Bot Updated [Time, Damage, Category, Investigating agency]
27-Nov-2017 20:37 ASN Update Bot Updated [Other fatalities, Departure airport, Destination airport, Source, Narrative]
13-Mar-2022 04:34 Captain Adam Updated [Other fatalities, Location, Departure airport, Destination airport, Source, Narrative, Photo]

Corrections or additions? ... Edit this accident description

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org