ASN logo
ASN Wikibase Occurrence # 202494
Last updated: 14 December 2018
This information is added by users of ASN. Neither ASN nor the Flight Safety Foundation are responsible for the completeness or correctness of this information. If you feel this information is incomplete or incorrect, you can submit corrected information.

Date:03-DEC-2017
Time:c. 17:00 LT
Type:Silhouette image of generic E190 model; specific model in this crash may look slightly different
Embraer ERJ-190LR
Owner/operator:Nordic Regional Airlines, opf Finnair
Registration: OH-LKE
C/n / msn: 19000059
Fatalities:Fatalities: 0 / Occupants: 104
Other fatalities:0
Aircraft damage: Minor
Category:Serious incident
Location:near Kemiö -   Finland
Phase: En route
Nature:International Scheduled Passenger
Departure airport:Helsinki-Vantaa Airport EFHK
Destination airport:Göteborg Airport ESGG
Investigating agency: AIB Finland
Narrative:
On December 3, 2017, scheduled flight call sign AY865, operated for Finnair by Nordic Regional Airlines, departed from Helsinki-Vantaa Airport, Helsinki, Finland, to Gothenburg, Sweden. The flight diverted to Turku, Finland, after smoke was observed on board. The captain decided to evacuate the airplane after landing. The Embraer ERJ 190-100LR carried 100 passengers and four crew members. The occurrence did not result in injuries.
After takeoff, the flight crew noticed oscillations in the pressurization system and received an indication of a fault in automatic pressurization control. Soon afterwards, they smelt smoke, and the captain decided to return to Helsinki. The chief of cabin notified the flight crew of smoke and "burning smell" in the cabin. Upon receiving is information, the captain declared emergency. Shortly afterwards, a PACK 1 FAIL message displayed, indicating the failure of one of the airplane’s two air conditioning packs. The captain actioned the appropriate checklist, and the flight crew elected to divert to Turku. Since smoke was also evident in the cockpit, they donned oxygen masks. One of the two cabin crew members attempted to don protective breathing equipment (PBE) but was unable to open the protective bag.
Smoke intensified after landing, and therefore the captain decided to evacuate the airplane on a link taxiway. Although the cabin crew ordered the passengers to leave baggage behind, several passengers grabbed their carry-ons. The doors were opened, and the slides deployed. The overwing exits were also opened and used by a number of passengers to evacuate onto the wings, Since no fire was observed inside the airplane, the rescue crews told these passengers to re-enter the cabin and evacuate via the slides.

Technical examination revealed that the cause of smoke was the failure of journal bearings in the left-hand air cycle machine that had been fitted in the airplane during manufacture.
Tests also showed that a pull of approximately 25 kp would have been needed to open PBE bags. The task would have been easier had the bags been modified according to the manufacturer's non-mandatory service bulletin. Difficulties in the opening of a bag may jeopardize a crew member's life and health.
Investigation found that the current alerting service manual issued to air navigation service units guide the controller to classify a possible or confirmed inflight fire as a full emergency situation. Therefore, the Southwestern Finland Emergency Response Center did not direct the region’s hospitals to elevate readiness.
Since several passengers wore only light clothing and outside temperature was only three degrees above zero, passengers began to feel the cold after evacuation. They were transported from the movement area to the evacuation point in local buses that were requisitioned pursuant to the Rescue Act. The procedure was unplanned and had therefore not been rehearsed. Under certain weather conditions moving of the passengers from the accident site without undue delay will be essential.

Sources:

http://www.onnettomuustutkinta.fi/en/index/ajankohtaista/aloitetuttutkinnattiedotteet/l2017-06liikennelentokoneenevakuoiminenmatkustamossaolleensavunvuoksiturunlentoasemalle3.12.2017.html
https://www.aftonbladet.se/nyheter/a/vmQOLX/finnair-plan-fick-nodlanda-i-abo
http://www.lentoposti.fi/uutiset/finnairin_g_teborgin_lento_teki_h_t_laskun_turkuun_savun_hajua_matkustamossa
http://www.lentoposti.fi/uutiset/ensimm_inen_finnairin_koneen_h_t_liukuevakuointi_otkes_l_ysi_embraerin_savuhavainnon_syyn
https://www.flightradar24.com/data/aircraft/oh-lke#fb86e5d

Accident investigation:
cover
  
Investigating agency: AIB Finland
Status: Investigation completed
Duration: 12 months
Download report: Final report


Revision history:

Date/timeContributorUpdates
04-Dec-2017 07:28 penu Added
04-Dec-2017 07:42 harro Updated [Cn, Operator, Source, Embed code, Narrative]
04-Dec-2017 07:58 Aerossurance Updated [Time, Location, Embed code]
04-Dec-2017 19:19 penu Updated [Total occupants, Source, Narrative]
13-Dec-2017 21:24 harro Updated [Operator, Source]
02-Dec-2018 16:04 harro Updated [Damage, Narrative, Accident report, ]

Corrections or additions? ... Edit this accident description